The VX800 Specifications Page
 

TORQUE CHARTS

SERVICE DATA

DYNO ROLLING ROAD TEST RESULT

  Carburetor Specifications

 

 
The series of symbols on the left stand for the countries and areas on the right.
 
 

COUNTRY OR AREA

E-01 General market (Export standard model)
E-02 England
E-03 USA (except California)
E-04 France
E-15 Finland
E-16 Norway
E17 Switzerland
E21 Belgium
E22 West Germany
E24 Australia
E25 Netherlands
E28 Canada
E33 California (U.S.A.)
E34  Italy
E39 Austria
E53 Spain

 

 

SPECIFICATIONS, DIMENSIONS AND DRY MASS
Overall length  2280 mm (89.8 in)...
E15, 16,17,22,25,39       2355 mm (92.7 in) . .
E18 2255 mm (88.8 in).. 
Overall width 805 mm (31.7 in)
Overall height 1115 mm (43.9 in)
E03, 28,33 1085 mm (42.7 in) 
Wheel base  565 mm (61.6 in)
E03, 33 1555 mm (61.2 in)
Ground clearance 145 mm ( 5.7 in)
Seat height 800 mm (31.5 in)
E01, 03,28,33 795 mm (31.3 in) 
Dry mass  214kg (4721bs)
E33 213kg (470 lbs)

 

 

ENGINE
Type Four-stroke, water-cooled, OHC, TSCC 450 V-twin
Valve clearance 0.08-0.13 mm (0.003 - 0.005 in)
Number of cylinders 2
Bore 83.0 mm (3.268 in)
Stroke 74A mm (2.929 in) 
Piston displacement 805cm3 (49.12cu. in)
Compression ratio  10,0 :1
Starter system  Electric starter motor 
Lubrication system  Wet sump

 

Carburetors
Front  MIKUNI 80S36SS, single
Rear  MIKUNI BSS6SS, single 
Air cleaner  Polyester fiber element 

Click here for Carburetor specifications

    

 

TRANSMISSION
Clutch  Wet multi-plate type 
Transmission 5-speed constant mesh
Gearshift pattern 1-down, 4-up
Primary reduction ratio  Gear ratios
Low 1.690(71/42)
2nd 2.285(32/14)
3rd 1.631 (31/19)
4th 1.227 (27/22)
Top 1.000(25/25)
Secondary reduction ratio 0.851(23/27) - 1.133(17/15x30/30)...E03,33
Final reduction ratio 1.096(17/15 x 30/31). Others3.090(34/11)

Drive system                       Shaft drive

 

 

CHASSIS
Front suspension  Telescopic, coil spring, oil damped
Rear suspension Swingarm, coil spring, gas/oil damped, spring preload 5-way adjustable; rebound damping force 4-way adjustable 
EO1,03,28,33;compression damping force 4-way adjustable and rebound damping force 4-way adjustable...
 Front suspension stroke 150 mm (5.9 in) Rear wheel travel 118mm (4,6 in). EO1,03,28,33 
.119 mm (4.7 in)... Others 
Steering angle 35° (right & left)
Caster 59°
Trail  143 mm (5.63 in)... E01, 03, 28, 33
142 mm (5.59 in) ... Others 
Turning radius  3.2m(10.5 ft) 
Front brake Disc
Rear brake  Disc
Front tire size  110/80-18 58H, tubeless
Rear tire size 150/70B17 69H, tubeless

 

   

ELECTRICAL

Electrical System Wiring diagram
Ignition type  Fully transistorized
Ignition timing  5° B.T.D.C. below 1650 r/min and 30° B.T.D.C. above 3500 r/min... E03, 33 T.D.C.below 1625 r/min and 30° B.T.D.C. above 3500 r/min... E18 
5° B.T.D.C. below 1625 r/min and 32° B.T.D.C. above 3750 r/min. .. Others 
Spark plug  NGK DPR8EA-9 or NIPPON DENSO X24EPR-U9 
Battery 12V  (l6Ah)/10HR
Fuse 25/10/10/10A 
Headlight 12V 60/55W 
Position light  12V 4W... except E03, 28,33
Turn signal light  12V 21W 
Tail/Brake light  12V 5/21W
License plate light  12V 5W 
Speedometer light  12V 3.4W 
Tachometer light  12V 1.7W 
Neutral indicator light  12V 3.4W 
High beam indicator light  12V 1.7W 
Turn signal light indicator light  12V 3.4W
Oil pressure indicator light  12V 3.4W 
Coolant temperature check light 12V 3W

 

CAPACITIES
Fuel tank, including reserve  18.0 L (4.8/4.0 US/Imp. gal) ... E33
19.0 L (5.0/4.2 US/Imp. gal) ... Others
Reserve  4.0 L (1.1/0.9 US/Imp. gal)

Engine oil

oil change 

  2,400 ml (2.5/2.1 US/Imp. qt) 

with filter change 

 2800 ml (3.0/2.5 US/Imp. qt)

overhaul 

 3300 ml (3.5/2.9 US/Imp. qt)
Final gear oil  200 - 220 ml (6.8/7.0 - 7.4/7.7 US/Imp. oz)
Coolant (including reserve)  1700 ml (1.8/1.5 US/Imp. qt) 
Front fork oil (each leg)  388 ml (13.1/13.7 US/Imp .. E01,03,28,33
 392 ml (13.2/13.8 US/Imp...) ... Others 
 (If you have Progressive springs, you must have approx. 290 ml)